This page is read only. You can view the source, but not change it. Ask your administrator if you think this is wrong. # Veg oil motoring  --- > "The use of plant oil as fuel may seem insignificant today. But such products can in time become just as important as kerosene and these coal-tar-products of today." - Rudolf Diesel ## What is veg oil motoring? Rudolf Diesel's [first engine ran on vegetable (peanut) oil](https://en.wikipedia.org/wiki/Rudolf_Diesel#Use_of_vegetable_oils_as_Diesel_engine_fuel). You can do the same thing today, but some modifications to your diesel vehicle will be necessary for veg oil motoring (it’s not possible to convert petrol vehicles to run on vegetable oil). Veg oil is too viscous to use directly in an unmodified vehicle, so there are two ways that viscosity can be reduced: 1. Remove the glycerine from the oil to make [biodiesel](/biod/biodiesel), in which case no vehicle conversion is necessary. 3. Convert the vehicle to use straight oil (which reduces viscosity by pre-heating the fuel). <WRAP center centeralign> <figure>  <caption> _Yes, you can run your (diesel) vehicle on this stuff (after you've cooked with it first) – but you’ll have to convert your vehicle to avoid damage due to its extra viscosity._ </caption> </figure> </WRAP> Biodiesel can be used in any diesel vehicle, and mixed with mineral diesel in any ratio. Straight vegetable oil should not be used in an unconverted diesel vehicle, due to its viscosity, and the fact that the glycerine content may cause ‘coking’ of fuel injector heads and possible engine failure. It’s perfectly legal despite the reports of arrests in Wales for driving on veg oil (they weren’t paying road fuel duty). ## What are the benefits of veg oil motoring? Vegetable oil is a biofuel, and as such is virtually carbon-neutral. This means that the carbon dioxide (CO2) released when the fuel is burnt is absorbed by the plants that will provide the next crop of oil (although we only support the use of cleaned, waste cooking oil - see below). <WRAP center centeralign> <figure>  <caption> _Land’s End to John O’ Groats: [Daniel Blackburn](http://news.bbc.co.uk/1/hi/wales/south_west/3104763.stm), seen here beginning his journey to promote veg oil motoring. He filled up with cooking oil bought from shops on the way._ </caption> </figure> </WRAP> As CO2 is the main greenhouse gas, switching to biofuels can help to slow global warming. Emissions are cleaner too – sulphur is eliminated, and a range of other pollutants are reduced dramatically (including particulates, carbon monoxide, and unburnt hydrocarbons). Further benefits include: - Requires less energy to produce - Doesn’t have to be transported such long distances - Renewable resource - Non-toxic - Biodegradable These environmental benefits also apply to biodiesel, but if you’re sure that your car is worth a conversion to be able to use straight vegetable oil, this is a more environmentally-friendly option, as there will be none of the problems associated with the waste from the biodiesel production process. <WRAP center centeralign> <figure> {{url>https://www.youtube.com/embed/9L5RMc3ZslQ 560,315}} <caption> _Mercedes pick-up owner explains how he converted his vehicle to run on waste cooking oil using a simple one-tank system._ </caption> </figure> </WRAP> ## What can I do? As the world moves towards electric vehicles, this topic becomes less relevant. However, we don't know what's around the corner, and diesel engines may be required for agriculture and distribution in case of breakdown of essential supply chains for whatever reason. Petrol vehicles can't be converted to run on veg oil – it's for diesel vehicles only. For more on which vehicles are more easily converted, see the discussion [here](https://axleaddict.com/cars/Waste-Vegetable-Oil-Fueled-Vehicles). <WRAP center centeralign> <figure>  <caption> _Once converted, you can fill up with veg oil, and away you go._ </caption> </figure> </WRAP> You can buy cooking oil in supermarkets, although we don't recommend virgin oil as it means using land to grow fuel for cars instead of food for humans. See [here](http://www.vegoilcar.co.uk/wvo_faq.php) for information about obtaining used cooking oil (cleaned or uncleaned); and [here](http://www.vegoilcar.co.uk/waste_vegetable_oil_wvo_buying.php) for advice about buying from eBay. The 2 main pump manufacturers in the UK are Bosch and Lucas. To run on veg oil a Bosch pump is preferable. Lucas pumps have a ‘paddle’ mechanism which can’t cope with the heavier veg oil. A good mechanic can swap a Bosch pump for a Lucas. <WRAP center centeralign> <figure> {{url>https://www.youtube.com/embed/05tsBL3kf_4 560,315}} <caption> _**[Veg Oil Guy](http://www.vegoilcar.co.uk/)** explains the two-tank system._ </caption> </figure> </WRAP> ### Two-tank method An extra tank is added for veg oil. You start with diesel, then switch to veg oil when the engine is hot, and it's continually heated via a heat exchange system. Before stopping, switch to the diesel tank again so that there will be mineral diesel in the fuel line when you come to start your car again. Cost installed c. £800. DIY kit c. £400 ### Simple one-tank method It’s simpler – you don’t have to remember to switch to mineral diesel near the end of your journey, and veg oil and mineral diesel can be mixed in the same tank. A simple one-tank conversion involves pre-heating the oil before it gets to the cylinders, and is only possible with indirect injection vehicles (D, TD, not DI, TDI, HDI, SDI etc.), because they have a separate chamber for atomising the fuel before it reaches the pistons, so cold starting on veg oil is fine. Also, a new, wider fuel line is installed between the fuel tank and the heat exchanger, because of the extra viscosity of vegetable oil. Cost installed c. £600. <WRAP center centeralign> <figure>  <caption> _A simple one-tank conversion involves the installation of a slightly larger diameter (because of veg oil’s viscosity), insulated fuel line._ </caption> </figure> </WRAP> ### Elsbett one-tank method [[http://www.elsbett.com|Elsbett]] is a German kit with a few installers in the UK. They've designed an engine where veg oil is the fuel and the coolant, so it gets continually heated. When starting from cold, there's an electrically-heated jacket on the fuel filter. However, they advise against using waste oil. In a conventional diesel engine, fuel is initially sprayed onto a heater plug at the top of the chamber (which is why you have to wait a few moments for the plug to heat up when starting a diesel engine); in an Elsbett conversion, the heater plug stays on until the engine is up to temperature. Cost installed c. £850-1300, depending on vehicle. DIY kit c. £550-750. More difficult than the other two conversions - a job for experienced mechanics only. <WRAP center centeralign> <figure>  <caption> _All the kit required for an Elsbett conversion of a Citroen ZX._ </caption> </figure> </WRAP> ### Paying duty Road fuel duty is payable for veg oil in the UK, but the rates change. Contact [HM Revenue & Customs](http://www.hmrc.gov.uk) for advice. ## Further resources - [Alternative Fuels Data Center](https://afdc.energy.gov/) - [Biofuel Systems](https://www.biofuelsystems.com/filters.htm) - filtration and other equipment - [Mother Earth News](https://www.motherearthnews.com/sustainable-living/green-transportation/run-a-diesel-vehicle-on-vegetable-oil-zmaz07djzgoe/) - run a diesel vehicle on vegetable oil - [Elsbett](https://www.elsbett.com/) - Elsbett Gmbh (Germany) - manufacturer of conversion kits (new oil only) - [How diesel engines work](https://auto.howstuffworks.com/diesel.htm) - [Journey to Forever](https://journeytoforever.org/biodiesel_svo.html) - discussions about using straight veg oil as a road fuel, plus comparisons with biodiesel - [VegBurner](http://vegburner.co.uk/report.html) - report on veg oil as a fuel - [WVODesigns](https://wvodesigns.com/wvo-conversion.html) - converting vehicles to run on waste vegetable oil (WVO), waste motor oil (WMO) and other alternative fuels. We have plenty of experience in weaning vehicle engines from expensive fossil fuels onto cost-effective green alternatives ## Related topics - [[biod:biodiesel|Biodiesel]] - [[recl:Recycling|Recycling, reusing & repairing]] - [[litr:transport|Low-impact transport]] ## Specialist curators of this topic vego/veg_oil_motoring.txt Last modified: 2026/03/12 18:32by asimong